I. Product Introduction Gimbaby's fast-burning biogas materials are the latest generation of products developed through comprehensive use of international high-end microbiological engineering technology, such as the United States, Japan and South Korea, combined with proprietary intellectual property rights and patented technologies. This product is a domestic natural composite good (consumption) oxygen-type fermentation bactericide, rapid fermentation temperature, simple operation, can be a variety of crop straw, forage, leaves and other fermentation decomposition and transformation, so that the straw in the lignin, fiber Compounds such as hormones, hemicelluloses, pectin, and waxes are destroyed, increasing the contact surface with bacteria, and thus being better decomposed and utilized by microorganisms, preventing crusting, rapid start-up, shortening gas production time, increasing gas production, and Improve gas efficiency and other aspects have a significant role.
Second, product characteristics
1, shorten the gas production time. Straw is difficult to digest, in which lignin, fiber, etc. are difficult to be decomposed, so the straw is quickly pretreated by the golden robber fast rot agent after rapid aerobic fermentation, and then the fermented straw is put into the biogas tank, which can greatly reduce the decay time. In order to enter the gas production stage in advance, more than 60% of the time is saved compared to natural stacking.
2, to prevent crusted obstacles. The surface of the straw has a layer of wax that is not easily destroyed by the biogas microorganisms. If the straw directly under the pool will be a lot of floating crust, it is difficult to be decomposed and fully utilized by fermentation, which significantly affects the gas production and gas production efficiency, so before entering the pool with Gem biogas fast rot pretreatment after it was destroyed (Fermentation, softening, rot) can increase gas production by 30-50%.
3, improve gas production efficiency. After the raw material is pretreated, the fermentation time in the pool is naturally reduced, and the inlet temperature can meet the requirements and start gas production. If the raw material is used together with the Gambo Biogas Fermenting Agent, the startup time can be reduced by more than half and can be increased. 50-100% of gas production, gas production is even and stable, and save a lot of manpower time and cost.
Third, the use of methods
1. Prepare raw materials. The first straw or straw 10-15 (dry weight of about 1-2 tons) with a guillotine cut into 60 millimeters or so short standby, conditional can be kneaded or crushed, this can not only damage the waxy surface of the straw, but also The contact area between the fermentation raw material and the bacteria is increased, which can speed up the decomposition and utilization of raw materials. After shredding and kneading, the comminuted straw under the pond is fermented, and the general gas production can be increased by about 20%.
2, built a heap of bacteria. 2.5 kg of urea (which can also be replaced with 250 kg of poultry manure) is mixed with 150-200 kg of water to make urea water and evenly thrown in the straw material. The water content of the material is required to reach 60-70% (whether the moisture is suitable or not. Method: hand grasping a handful of material, see the water does not drip, landing that is appropriate scattered), wait until the urea water soaked in material, and then into a pile (high 1 meter, 1.5 meters wide, long arbitrary), must be done Heap pressure, try to reduce the volume. Cover it with a breathable cover and place it naturally for 12-24 hours.
On the second day, mix 1 kg of gilt biogas fast rot and 5-10 kg of rice bran (or Fufu, corn flour) and mix evenly, and then evenly spread it in the piled straw material, so that it can be splashed and sprinkled. Sprinkle the goldfish fermentation strain and cover it with a breathable covering to protect it from light and rain.
3, warming fermentation. Stacking time is 2 to 3 days in summer and 3-5 days in winter. When the stack is hot and hot (50～60°C), it can be piled up once and put it into the heap outside the pile, and add some water (not too much). Most of the straw color is soft from yellow to black Or it becomes brown and it is broken by hand. At this time, it can be put into the digester to produce gas.
Straw and other materials are subjected to aerobic fermentation pretreatment, and then put into the biogas digester. In combination with the use of Gum Biogas fermentation agent, the gas production rate, gas production, and gas production efficiency can be greatly increased. Details can visit the website or consult.
Best Wrist Blood Pressure Monitor ,Wrist Cuff Blood Pressure Monitor,Hylogy Blood Pressure Monitor,Touch Wrist Blood Pressure Monitor
Shenzhen urion Technology Co., Ltd. , https://www.urionhealth.com